The HT centerstand tucks in nicely once everything is folded up; it just has to be the last stand lowered or the first one raised. Panniers & Top Boxes > KLR650 Pannier Width. No locks to mess with 6. The Photo below is a shot taken on the Siberian Highway.BTW, be sure to beef up your Sub frame, and get extra high tinsel strength bolts for the sub frame. That’s what the guys at Happy Trails asked themselves, and the answer was a resounding yes in the form of an adjustable bolt-on centerstand for KLR650 models.If you’ve ever installed an aftermarket centerstand, here’s the best news first—the Happy Trails centerstand comes out of the box as a single piece, fully assembled, with the springs already in place. Happy-Trail.com / McDonald's Products Heavy Duty Folding Shifter Review Reviewed by Hondo Feb 6, 2007 One of the weakest parts on the Kawasaki KLR650 is the stock gear shifter lever, with many reports of the stock lever failing and stranding riders. Chose them over SW Motech based on the fact that the H-T's come up further on the side of the cowls. Upon picking the bike up I noticed the left cowl was scratched from the top tube of the nerf bar.
Read TRAIL-DUST Blog . I've never heard anything bad about them. Initially I'm planning to go the 20mm ammo box route but later may opt for aluminum boxes. Happy Trails Engine Guards are constructed from 1" steel tube. From what Ive seen in my travels, they are the sturdiest system available, not pretty, but very stout. Crashbars > Happy Trails PD Plus Skid Plate for Kawasaki KLR650E '08-up; Happy Trails PD Plus Skid Plate for Kawasaki KLR650E '08-up. Weatherproof locking mechanism panniers to lock outside view Lock to install back side of packaging need to shim …
The KLR I put the stand on had Happy Trails 1.5-inch lowering links, so HT sent along a pair of 1-inchers to replace them. $369.95. MPN: P4-8-5BPlus. Happytrails gets my vote.
The locks will be installed on Happy Trails aluminum panniers on a KLR650. Fit was great. Money is not a consideration; I want the best money can buy. This alone represents a tremendous savings in sweat, skinned knuckles and profanity. Easy open/close 4. My choice for panniers is Happy Trails. Most dual-sport riders have a lift or a set of stands in the garage to ease routine maintenance on the chain, or change tires or oil. Personally, I like Happy-Trails as a company, and have their racks and PD Nerf bars. Provide keyless permanent locking system 2.
I have found only two mount systems - Happy Trails ($239 for their "SU" heavy duty version or $199 for their "NW" lightweight), and KLR650.com's ($233). The centerstand mounts to the bottom of the frame, inboard of the footpegs; just remove the pegs, slide the stand up from below, and use the longer bolts that come with the kit to replace the footpegs (and remember, blue Loctite is your friend.
I'd probably go with the KLR650.com ones. The centerstand has already justified its presence with easier chain maintenance, and it also makes checking engine oil before each ride faster since the bike needs to be held vertically to check the sight glass. The KLR I put the stand on had Happy Trails 1.5-inch lowering links, so HT sent along a pair of 1-inchers to replace them. Out on the trail, though, those jobs get tougher, especially if one of the only two wheels the bike sits on has to be removed to fix a flat. Since the raised stand hangs under the frame where it can hit the pavement during spirited cornering, Happy Trails says 1 inch is as far as you should lower the rear end. Gee, wouldn’t a centerstand be handy right about then? In Stock. First ride out with them I went down at slow speed in deep sand.
And if I ever get a flat out on the trail…well, let’s not think about that.Happy Trails Centerstand for Kawasaki KLR650 Review When you come to a stop you’ll probably put the sidestand down first anyway; just leave it down until you’re back on two wheels and ready to go.The KLR is popular with riders of all inseam lengths, so the centerstand is adjustable to accommodate stock or lowered rear suspension. )That’s all there is to it, except remembering that you have to deploy the sidestand before putting the bike on, or taking it off, the centerstand, or the centerstand’s foot will hit the sidestand. Ships in 4-5 days Quantity: Product Descriptions . But, you could almost buy two sets of the KLR650.com panniers for the price of the Happy-Trail ones. Works great with the 30mm ammo boxes, which are 14x17x9 inches and have about 35L of displacement each.Go with the Happy trails panniers/Racks. The intent of the locks are: 1. Detour thieves with high profile lock 3.
Looked solid enough. Money well spent. Just got a new KLR and need luggage. Retail: $ 444.44 Savings: $74.49 (17%) Code: HTP4-8-5BPlus. I installed the PD Nerf bars from Happy Trails on my '08 KLR. Happy Trails is proud to offer the finest custom engineered luggage systems and products to enhance the use, safety and enjoyment of your Dual Sport & Adventure Touring needs.
Happily, their installation was made much easier by putting the bike on the newly installed centerstand.The adjustable centerstand sells for $149.95 and fits the 1987-2007 model KLR650; the steel lowering links sell for $49.95 a pair for the same years and model, and also come in 0.5- and 1.5-inch applications.